FAQ: Suzuki: Hayabusa (Gen2)

  1. Will I need a new map if I take out the secondary butterflies on my 05 Busa?
  2. Will an intake cam on the exhaust side work with my slip on GP style short pipes on my 09 Hayausa? Or do I need to change the whole exhaust system for it to work?
  3. Will a Gen1 clutch cushion kit work in a Gen2 Busa?
  4. Why not remove the bracket altogether instead of just the 3 screws holding the PAIR valve block off kit for a 99-07 Hayabusa?
  5. Why does the idle increase after about 10 minutes of riding on my 1361 Hayabusa with basic head clean up and Alien Head system?
  6. When using the Brock’s Performance Clutch Cushion Kit in my Hayabusa, what year OEM replacement clutch should I purchase?
  7. What is the best oil and weight to run in my 1397 Hayabusa.
  8. What clutch spring setup would be good for my high horsepower Hayabusa and how much can it handle?
  9. Should I expect to see any HP gains going from the Gen3 to the Sidewinder on my Busa?
  10. Should I buy the TRE or X-TRE for my 2009 Hayabusa?
  11. On an 08-12 Busa does the stock oxygen sensor go back in the exhaust? The opening for it is blocked off.
  12. Need video on how to install Brock’s alien head 4 into 2 into 1 full system on my 2007 hayabusa
  13. If I use the 99-07 clutch cushion do I also have to use the 99-07 fibers along with the spring studs or can I use the 08 fibers along with the 99-07 spring studs?
  14. If I use a lockup clutch, can I use a cushion kit? How do I know if I need new clutch components?
  15. I was planning to set up my 08 Busa exactly how I had my 03 because I was so happy with its performance. Stock motor, your mods, street pipe, 6″ over arm, 16 42 gearing, 40 hp dry kit =9.0s @154 1.50s 60′ (I weigh 220 in shorts) but with the new 08 (stroke) I’m unsure??? Any advice would be GREAT!
  16. I thought I might have an exhaust leak around the header flanges, so I took my bike (08 Busa) to the dealership and had the exhaust gaskets replaced. The sound is still there and they say it is common with aftermarket exhausts. Is this the case?
  17. I just purchased a 2008 Busa and wanted to ask about the Alien head pipe and what type of map should I request. Which one (map) would give me the most power for street use?
  18. I just bought a Billet Cam Chain Tensioner and I was wondering if you had the spec on how to put the right amount of tension on the chain or how to set it up?
  19. I have a 2008 Suzuki Hayabusa and I purchased one of your CT single exhaust systems. What torque spec do you use on the header flanges?
  20. I have a Hayabusa with your clutch mod and cushion. For some reason the clutches don’t last long. What could be the problem?
  21. I currently have an alien head on my Gen 2 Busa and the header is slightly smashed, so I’m considering getting your 4-2-1 sidewinder. My question is, what type of power increase can I expect with your 4-2-1 sidewinder, running it without a baffle. Basically I would like to know the advantages of a sidewinder.
  22. I am looking at your “Top End engine package” or the “piston kit with cams” for my Hayabusa. Assuming that these packages increase compression ratio, what octane fuel is needed to assure reliable operation? The best fuel I have around here is 90 octane at the pump.
  23. I am considering installing your Alien Head exhaust system on my 2011 Busa and a Power Commander V with your street map pre installed. My bike is completery stock with less than 2000 miles on it. Will I hear deceleration pop or backfire from this exhaust system with the power commander installed and mapped by you?
  24. My bike runs horribly, is it the map?
  25. getting to purchase power commander 5 and an auto tune…Question does the alien head have an o2 hole? Is the auto tune a good idea?
  26. Dyno Testing with a Sidewinder – baffle in or baffle Out?
  27. Does the Speedo Healer also disable or sneak its way around the factory speed limiter ?
  28. Does the oil cooler have to be removed to install a Sidewinder on my 2006 Hayabusa?
  29. Do TREs alter the Air/Fuel ration on the 08 Hayabusa?
  30. Do I need a different map for each setting to use the S-DMS (Suzuki Drive Mode Selector) on my bike.
  31. Can the TiWinder be used with the stock oil pan or does it have to be installed with a lower profile oil pan? On the 08 Busa, can the oil cooler still be used with this exhaust?
  32. Can I use the “08 or “09 Busa clutch plates and fibers (the proper numbers) setup on my “05 busa (in the brock clutch- Mod sequence)?
  33. Regardless of the style/type of lowering links you offer, do I need to additionally purchase a shortened kickstand? I’m looking at the adjustable models for racing – will the stock kickstand still support the bike if I have dropped the rear?
  34. Why don’t you provide Ignition Mapping for your exhaust systems?
  35. My Suzuki misses and stalls abruptly when I pull the clutch lever in. Do I need a Map, or is my Power Commander bad?
  36. Do you have a gear ratio calculator?
  37. Why has my FI light started coming on when the bike is decelerating? I cut the wires at the pressure switch for the clutch.
  38. How much power can the Clutch Cushion kit hold for the GSXR1000 and Hayabusa? I have a lock up and i’m having problems.
  39. I currently have a Gen 3 on my Hayabusa. Will I need a different MAP if I install the Sidewinder?
  40. Does a TRE make the motorcycle accelerate more slowly when shifting through gears due to the TRE being set at a specific gear?
  41. Will a Power Commander hurt my stock 2009 Hayabusa with only 1 mile on it?
  42. I notice a huge difference in the Pump Gas Track map fuel added at 100% throttle starting at around 7k rpm’s compared to the other maps. Is this correct?
  43. I have mounted the clutch cushion kit on my Busa. Now I’m mounting a lock up clutch. Do I have to do anything with the spring pressure or will the springs that followed the cushion kit work well?
  44. I have cams from my Gen 2 Hayabusa LSR bike that I’d like to use in my Gen 1 bike. I see your offset cam pin for going from Gen 1 to Gen 2, can I do the opposite? (Gen 2 cams in Gen 1 motor).
  45. I have a 2008 Hayabusa with the following items; Power Commander with your supplied Map, Air Shifter, Brock’s Exhaust system. I’m running 9.4 the 1/4 of mile. Someone told me that the ignition module is necessary to run below the 9 seconds. Can you provide some advice?